Wednesday, November 26, 2014
FAIRFIELD-SUISUN, CALIFORNIA
99 CENTS

FAA proposes to fine Southwest Airlines $12M

Southwest Airlines Fine

In this June 19, 2014 photo, a Southwest Airlines Boeing 737 is serviced at Bill and Hillary Clinton National Airport in Little Rock, Ark. The Federal Aviation Administration on Monday, July 28, 2014 is proposing a $12 million civil fine against Southwest Airlines for failing to comply in three separate cases with safety regulations related to repairs on Boeing 737 jetliners. (AP Photo/Danny Johnston)

By
July 29, 2014 |

WASHINGTON — The Federal Aviation Administration said Monday it is proposing a $12 million civil fine against Southwest Airlines for failing to comply with safety regulations related to repairs on Boeing 737 jetliners.

It is the second-largest fine the agency has proposed against an airline. The largest proposed fine was against American Airlines for $24.2 million in August 2010. That one was ultimately settled for $24.9 million as part of American’s bankruptcy proceedings, although the final settlement included other safety violations not part of the original proposal.

The FAA said that beginning in 2006 Southwest made “extreme makeover” alterations to eliminate potential cracking of the aluminum skin on 44 jetliners. An FAA investigation determined that Southwest’s contractor, Aviation Technical Services Inc. of Everett, Washington, failed to follow proper procedures for replacing the fuselage as well as other work on the planes, the agency said. All of the work was done under the supervision of Southwest, which was responsible for seeing that it was done properly, the FAA said.

Southwest, which is based in Dallas, then returned the planes to service in 2009 and began flying them even after the FAA “put the airline on notice that these aircraft were not in compliance” with safety regulations, the agency said.

During its investigation, the FAA also found that Aviation Technical Services’ workers applied sealant beneath the new skin panels but did not install fasteners in all of the rivet holes fast enough for the sealant to be effective.

“This could have resulted in gaps between the skin and the surface to which it was being mounted. Such gaps could allow moisture to penetrate the skin and lead to corrosion,” FAA said.

The contractor also failed to follow requirements to properly place the planes on jacks and shore them up while the work was being performed, the FAA said. If a plane is shored improperly during skin replacement, the airframe could shift and lead to subsequent problems with the new skin.

The FAA also said that Southwest failed to properly install a ground wire on water drain masts on two of its Boeing 737s in response to a safety order aimed at preventing lightning strikes. The planes were each operated on more than 20 passenger flights after Southwest Airlines became aware of the discrepancies but before the airline corrected the problem, the agency said.

“The FAA views maintenance very seriously, and it will not hesitate to take action against companies that fail to follow regulations,” said FAA Administrator Michael Huerta.

Southwest Airlines has 30 days to respond to the proposed fine. Usually FAA officials negotiate extensively with an airline in cases of large fines before settling upon an amount. However, regulators and airline officials sometimes are unable to reach an agreement and the airline contests the fine.

Brandi King, a spokeswoman for Southwest, said the airline will “respond to the FAA allegations” in accordance with the agency’s procedures.

“Having fully resolved the repair issues some time ago, none of the items raised in the FAA letter affect aircraft currently being operated by Southwest Airlines,” she said. “As always, Southwest is committed to continuously making enhancements to our internal procedures, as well as improvements related to oversight of our repair vendors.”

 

The Associated Press

The Associated Press

LEAVE A COMMENT

Discussion | No comments

The Daily Republic does not necessarily condone the comments here, nor does it review every post. Read our full policy

  • Recent Articles

  • Enter your email address to subscribe and receive notifications of new posts by email.

  • .

    Solano News

     
    Groups distribute Thanksgiving food

    By Ryan McCarthy | From Page: A1, 3 Comments | Gallery

     
     
    County fair proposal, budget topics of scrutiny

    By Amy Maginnis-Honey | From Page: A3 | Gallery

    Police: Vehicle burglaries not new for Fairfield

    By Susan Hiland | From Page: A3

     
    Library schedules soap-making program

    By Glen Faison | From Page: A4

     
    Vacaville PD seeks VIPS program volunteers

    By Glen Faison | From Page: A4

     
    Fairfield police offer free gun locks

    By Ian Thompson | From Page: A4, 1 Comment

     
    Fairfield police investigate shooting

    By Susan Hiland | From Page: A4

     
    Science comes to libraries – for all to see

    By Glen Faison | From Page: A5

    Soroptimists seek award applicants

    By Glen Faison | From Page: A5

     
     
    Nichols plans free family concert in Napa

    By Glen Faison | From Page: A7

    Church’s holiday soiree on Vacaville calendar

    By Glen Faison | From Page: A7

     
    Suisun City police log: Nov. 24, 2014

    By Susan Hiland | From Page: A9

     
    Fairfield police log: Nov. 23, 2014

    By Glen Faison | From Page: A9

    Fairfield police log: Nov. 22, 2014

    By Glen Faison | From Page: A9

     
    Suisun City police log: Nov. 23, 2014

    By Glen Faison | From Page: A9, 1 Comment

    Suisun City police log: Nov. 22, 2014

    By Glen Faison | From Page: A9

     
    Weather for Nov. 26, 2014

    By Daily Republic | From Page: B12

    .

    US / World

     
    Anger at Ferguson case based on emotion, evidence

    By The Associated Press | From Page: A1, 5 Comments

    Tough to make a case against police in shootings

    By The Associated Press | From Page: A1

     
    Protesters return to riot-scarred Ferguson streets

    By The Associated Press | From Page: A1, 1 Comment

    In Seattle, tofu turkeys get Thanksgiving pardons

    By The Associated Press | From Page: A2, 1 Comment

     
    Los Angeles freeway sign unveiled with typo

    By The Associated Press | From Page: A2

    Heirloom ring flushed; sewer workers retrieve it

    By The Associated Press | From Page: A2

     
    Ohio family recovers missing Sasquatch statue

    By The Associated Press | From Page: A2

    Auction fetches $28K for 1st batch of new bourbon

    By The Associated Press | From Page: A2

     
    Agreement: LA jails to improve wheelchair access

    By The Associated Press | From Page: A5

    Window washer fights for life after 11-story fall

    By The Associated Press | From Page: A5

     
    Oakland police arrest more than 40 protesters

    By The Associated Press | From Page: A6

    Lawmakers target Golden Gate Bridge sidewalk fee

    By The Associated Press | From Page: A6, 1 Comment

     
    Cosby philanthropy shadowed by sexual allegations

    By The Associated Press | From Page: A6

    Arkansas, Mississippi gay marriage bans overturned

    By The Associated Press | From Page: A10, 1 Comment

     
    Calorie count to appear with many prepared foods

    By The Associated Press | From Page: A10

    8 shoes of Holocaust victims stolen in Poland

    By The Associated Press | From Page: A11

     
    Activists: Syrian strikes kill 60 in IS-held city

    By The Associated Press | From Page: A11

    AP sources: Top candidate for defense job bows out

    By The Associated Press | From Page: A11, 2 Comments

     
    WWII Museum opening new pavilion in New Orleans

    By The Associated Press | From Page: A11

    Police: Students ran high school prostitution ring

    By The Associated Press | From Page: A11

     
    Wet basements in Buffalo as flooding fears ease

    By The Associated Press | From Page: A11

    Soldiers to spend Thanksgiving in Ebola isolation

    By The Associated Press | From Page: A11

     
    2 teen female bombers kill more than 40 in Nigeria

    By The Associated Press | From Page: A11

    Official: Afghan president orders military review

    By The Associated Press | From Page: A12

     
    .

    Opinion

     
    Senate staff cuts reduce transparency

    By Dan Walters | From Page: A8

     
    Hagel: The fall guy

    By David Rothkopf | From Page: A8

    .

    Living

    Community Calendar: Nov. 25, 2014

    By Susan Hiland | From Page: A2

     
    Community Calendar: Nov. 26, 2014

    By Susan Hiland | From Page: A2

    Today in History: Nov. 26, 2014

    By The Associated Press | From Page: A2

     
    Horoscope for Nov. 26, 2014

    By Holiday Mathis | From Page: B5

    The man I’m seeing makes no effort to get to know my kids

    By Kathy Mitchell and Marcy Sugar | From Page: B5

     
    A do-ahead cornmeal biscuit to sop up your gravy

    By The Associated Press | From Page: B6

     
    Fresh take on an herb-roasted Thanksgiving turkey

    By The Associated Press | From Page: B6

    Turn turkey leftovers into a healthy dinner salad

    By The Associated Press | From Page: B6

     
    .

    Entertainment

    TVGrid

    By Daily Republic Syndicated Content | From Page: A7

     
    ‘Birdman’ leads Spirit Awards nominations

    By The Associated Press | From Page: A7

    .

    Sports

    Red Sox bring in Sandoval, Hanley Ramirez

    By The Associated Press | From Page: B1 | Gallery

     
    Vacaville Christian wins 3-0, advances to state quarterfinals

    By Marcus Lomtong | From Page: B1 | Gallery

    Curry powers Warriors past Heat 114-97

    By The Associated Press | From Page: B1

     
    49ers rookies shine in big roles, out of necessity

    By The Associated Press | From Page: B1

    Cousins, Kings beat Pelicans 99-89

    By The Associated Press | From Page: B1 | Gallery

     
    NFL, union discuss personal conduct policy

    By The Associated Press | From Page: B2

    Bama, FSU, Oregon, Miss St keep playoff rankings

    By The Associated Press | From Page: B2

     
    Messi sets European record with 74 goals

    By The Associated Press | From Page: B2

    Judge OKs Hernandez trial delay in 2012 killings

    By The Associated Press | From Page: B2

     
    Kurt Busch wins delay of Delaware court hearing

    By The Associated Press | From Page: B2

    Giants third base coach Tim Flannery retires

    By The Associated Press | From Page: B2

     
    AP source: Left-hander Jon Lester, Giants to meet

    By The Associated Press | From Page: B2

    Pats are unanimous No. 1 in AP Pro32 rankings

    By The Associated Press | From Page: B2

     
    .

    Business

    Rain, snow could mess up Thanksgiving travel

    By The Associated Press | From Page: B7

     
    New iPhones push Apple’s market cap past $700B

    By The Associated Press | From Page: B7

    Twitter lets merchants offer deals to its users

    By The Associated Press | From Page: B7

     
    US economy posts even stronger growth in Q3

    By The Associated Press | From Page: B7

    Thanksgiving travel woes? There’s an app for that

    By The Associated Press | From Page: B7

     
    US home price gains slow for 10th straight month

    By The Associated Press | From Page: B7

    Barbie dethroned by Team Elsa

    By The Associated Press | From Page: B7

     
    .

    Obituaries

    Esther Ringler

    By Nancy Green | From Page: A4

     
    Glenita Reyes McLaughliin

    By Daily Republic | From Page: A4

    Leslie “Esi” Gros

    By Nancy Green | From Page: A4

     
    .

    Comics

    For Better or Worse

    By Daily Republic Syndicated Content | From Page: B4

     
    Beetle Bailey

    By Daily Republic Syndicated Content | From Page: B4

    Baldo

    By Daily Republic Syndicated Content | From Page: B4

     
    Dilbert

    By Daily Republic Syndicated Content | From Page: B4

    Peanuts

    By Daily Republic Syndicated Content | From Page: B4

     
    Baby Blues

    By Daily Republic Syndicated Content | From Page: B4

    Pickles

    By Daily Republic Syndicated Content | From Page: B4

     
    Zits

    By Daily Republic Syndicated Content | From Page: B4

    Sally Forth

    By Daily Republic Syndicated Content | From Page: B4

     
    Rose is Rose

    By Daily Republic Syndicated Content | From Page: B4

    Get Fuzzy

    By Daily Republic Syndicated Content | From Page: B4

     
    Frank and Ernest

    By Daily Republic Syndicated Content | From Page: B4

    B.C.

    By Daily Republic Syndicated Content | From Page: B4

     
    Blondie

    By Daily Republic Syndicated Content | From Page: B4

    Garfield

    By Daily Republic Syndicated Content | From Page: B4

     
    Wizard of Id

    By Daily Republic Syndicated Content | From Page: B4

    Bridge

    By Daily Republic Syndicated Content | From Page: B5

     
    Word Sleuth

    By Daily Republic Syndicated Content | From Page: B5

    Cryptoquote

    By Daily Republic Syndicated Content | From Page: B5

     
    Sudoku

    By Daily Republic Syndicated Content | From Page: B5